In the early jet age, pilots had good reason to fear the F7U

The Gutless Cutlass.

The “Gutless Cutless” earned its nickname primarily from its underpowered engines. A Vought F7U-3 in May 1953. Greater St. Louis Air and Space Museum

In November 1951, at Patuxent River Naval Air Station in Maryland, Lieutenant Commander Edward “Whitey” Feightner received the call he had been waiting for. On the line was an admiral from Naval Air Training Command, who told him he had been selected for the Navy’s flight demonstration squadron, which would eventually adopt the name the Blue Angels (after a Manhattan nightclub).

“It’s a big thing to get a Blue Angel position,” says Feightner. “You get the royal treatment, travel the country, get to meet a lot of good people, have fun at airshows, do some great flying and some valuable recruiting for the Navy. There are few better jobs.”

Feightner had just one question: What airplane would the team fly?

“He said the F7U-1 Cutlass,” recalls Feightner, at the time a Navy test pilot with the most flight time in that very aircraft. “I told him I just resigned.”

Conceived in part from swept-wing, tailless research recovered from the German manufacturer Arado after World War II, the Chance Vought F7U Cutlass was a radical departure from not only every other naval aircraft, but just about anything in the air at that time. It had no tail. Its vast, swept wings (with an area totaling 496 square feet) were nearly as long from leading to trailing edge as they were from root to tip. Its monster nosegear—the first to be fully steerable—placed the pilot 14 feet in the air, and during carrier landings tended to collapse. It also had the first hydraulic system at high pressure: 3,000 pounds per square inch—twice the pressure of the systems on other Navy jets—and all-hydraulic flight controls with built-in “artificial feel,” which restored control-surface feedback to the pilot.

Besides being exotic, the Cutlass was burdened with immature systems. Its hydraulic system constantly leaked and lost pressure, and its engines, like those on most early jets, failed to produce the power expected of them.

Feightner’s impromptu resignation was not the first associated with the Cutlass. “I was in carrier division flight test,” he says. “Other than the factory test pilots, three [of whom] already got killed in the jet, only two other people had flown the Cutlass. One was the guy ahead of me in carrier division. He had gone out on a flight in this strange new thing and encountered major control system problems. He managed to avoid crashing, and when he came down he walked in, threw his helmet on the ground, and said, ‘I quit.’ ”

In the summer of 1951, Feightner began putting the F7U-1 through its paces. When the Blue Angels call came, he had already determined that the Cutlass was an airframe to be reckoned with. Just not by him.

“We determined right off the bat it wasn’t the answer,” says Feightner. “But the Navy wanted to get some time on it. I actually took it aboard ship and made 14 landings before the airplane broke in half right behind the cockpit during a landing.”

Why the push to showcase the aircraft? “It was politics,” Feightner says. “There were Congressmen, senators, and we had a couple of pretty senior officers who wanted their airplane to be the Blue Angels airplane.”

The team went with Grumman F9F Panthers instead, and relegated the Cutlass F7U-1 to the two soloists, Feightner and Lieutenant Mac MacKnight.

While the Panthers were grounded for fuel control problems in the spring of 1952, Feightner, in a blue and gold Cutlass, made his Blue Angels airshow debut, flying a one-man show for VIPs in Pensacola, Florida. “I rolled down there, hit the afterburner, and headed straight up,” he says. “We didn’t have any other airplane that could do that in those days. I just started to climb, then I lost the hydraulics. You couldn’t eject until you got to 1,500 feet, and I topped out at 1,100, then headed straight down. I have the stick [full aft] and nothing is happening. The ground is getting bigger and all of a sudden everything hooks up again and the airplane goes nur-ooop. So now I’m flying—but there is a row of trees at the end of the runway. I couldn’t get over them so I just picked out a space between two trees and carved a hole through them.” Streaming hydraulic fluid and wood pulp, Feightner wrestled the Cutlass onto the runway and even managed to taxi up to the crowd.

“There is dead silence. They saw me hit the trees and knew I had a big emergency. Everybody is waiting to see what would happen. I get out and step off and a big cheer went up. Admiral Price comes over and says, ‘Man, that was a real airshow.’ ”

Feightner and MacKnight flew the Cutlasses almost daily. They endured hydraulic system and landing gear failures, inflight engine fires, and, on one occasion, pieces of landing gear doors falling onto a grandstand, miraculously missing everyone. By June, the Panthers had returned to flight, and the Cutlass solos were cut.

None of the 14 F7U-1s built between 1950 and ’52 made it to squadron service. But there was a new F7U in the offing. Improvements included new engines, a longer, thicker, and sturdier airframe almost a third larger than the original, and additional access panels for easier maintenance. On December 20, 1951, the F7U-3 made its first flight.

“Our job was to test the Cutlass,” wrote F7U Navy test pilot—later astronaut—Wally Schirra in his autobiography, Schirra’s Space. “The company soon became Chancy Vought to us, for in our judgment the Cutlass was an accident looking for a place to happen, a widow maker.”

But in some respects, the F7U-3 showed promise. Cutlass drivers found a number of things to praise about their new ride: It was a stable bombing platform, nimble, fun to fly, and, with its strengthened airframe, almost unbreakable. Feightner loved the fighter’s roll rate, which at 570 degrees a second was three times that of most production jets.

The F7U became a staple in hobby shops. Oldsmobile appropriated the name for a 1954 sports coupe. The Cutlass also provided the inspiration for the hood ornament on the 1955 and ’56 Chevrolet Bel Air.

In the spring of 1954, after six years of flight testing, three carrier suitability trials, and almost a decade of development, the first of 13 F7U-3 Cutlass fleet squadrons became operational. Early squadrons found out that the new! improved! Cutlass was also the most complicated to maintain. “I flew around 380 hours in the jet and never once wrote Okay on the [maintenance] sheet,” Feightner says. “There was never nothing wrong with it.”

All high-performance jets of the era—the North American FJ-1 Fury, the Lockheed P-80 Shooting Star, the McDonnell F2H-2 Banshee—had their share of unique incidents and accidents, but the sheer number of high-profile Cutlass misfortunes was tough to beat. Like the time Vought test pilot Paul Thayer ejected from a flaming prototype in front of an airshow crowd on July 7, 1950. Or when Lieutenant Floyd Nugent ejected on July 26, 1954, only to watch the Cutlass, loaded with 2.75-inch rockets, fly serenely on, orbiting San Diego’s North Island and the Hotel Del Coronado for almost 30 minutes before ditching near the shore. When the left engine on Lieutenant Commander Paul Harwell’s Cutlass caught fire moments after takeoff on May 30, 1955, Harwell ejected and never set foot in the F7U again—giving him more time in a Cutlass parachute than in the actual aircraft. An electrical failure forced Tom Quillin to abort a training mission and declare an emergency. Quillin returned to base only to learn he was number three in the emergency landing pattern, behind two of the three other Cutlasses he took off with.

On December 11, 1954, during a low-altitude, high-speed pass before thousands of onlookers at the christening of the USS Forrestal at Newport News, Virginia, Lieutenant J.W. Hood’s F7U-3 suffered a wing-locking mechanism malfunction. The airframe came apart, an engine blew up, and Hood was killed when he was catapulted into the water. On July 14, 1955, before the first deployment of a Cutlass squadron at sea, an F7U-3M Cutlass pilot flying carrier qualifications off the coast of San Diego was waved off as too low on approach to the USS Hancock. In a sequence shot by Navy camera crews, the Cutlass, flown by Lieutenant Commander Jay Alkire, is descending, though its nose is pointing skyward. The landing signal officer sprints across the flight deck only moments before the Cutlass hits the carrier, breaks apart, and falls over the side as a fireball consumes the tail end of the ship. Alkire was killed.

The F7U-3 shared a design flaw with the F7U-1: two anemic Westinghouse jet engines. The company promised Vought and the Navy it could build an engine for the -3 that would generate 10,000 pounds of thrust in afterburner. By the time the J-46-WE-8A was delivered, Westinghouse had dropped the estimate by 10 percent. Later evaluations indicated it could put out no more than 6,100 pounds. And no existing engine would fit the Cutlass’ airframe.

Vought engineers, concerned about the kickback load on the nose landing gear actuator and mounting structure, added small turbines, powered by engine bleed air, to pre-spin tire on the nosegear tires to 90 mph. But the nosegear strut continued to fail, despite efforts to reinforce the structure by 30 percent. A weak drag link brace tended to give out during landing.

The USS Hancock, like most aircraft carriers of the day, had a straight deck (the switch to angled decks began in the mid-1950s). To come to a stop before running out of deck or into the aircraft parked at its far end, pilots were required to grab an arresting wire with the aircraft’s tailhook or rely on a series of canvas safety nets and metal cables. On November 4, 1955, when Lieutenant George Milliard tried to land, the tailhook on his Cutlass floated over all 12 arresting wires. Too low and slow to go around, Milliard went into the barrier, where the nosegear failed. The strut drove up into the cockpit and into the base of the ejection seat, triggering the ejection seat firing mechanism and knocking off the canopy. Milliard was launched 200 feet forward. He hit the tail of a Douglas A-1 Skyraider and later died of his injuries.

The Hancock’s skipper ordered every Cutlass off the ship. VF-124 spent the majority of its western Pacific cruise at the naval airfield in Atsugi, Japan. Two months later, after a Cutlass nosegear collapse on the Ticonderoga left its pilot with severe back injuries, the carrier’s skipper ordered the Cutlasses of VF-81 ashore at Port Lyautey, Morocco. “You got to understand, the commanding officer of a carrier is the lord, God, and everything else of that carrier,” says Don Shelton, who in the early 1950s was a Navy test pilot on the Cutlass program. “Most of them didn’t appreciate having the F7U aboard.”

“The skippers never really liked it because it took up a lot of space and they never could really do anything with the airplane,” says Feightner. “The Cutlass was pretty short-legged.” Soon after launching from a carrier, the pilots had to begin thinking about where to put the thing down. “They used to say if you put a 3,000-pound bomb on it, you couldn’t go far enough to keep from blowing up both you and the ship,” Feightner says.

Then there was the post-stall gyration.

On January 11, 1955, Lieutenant J.D. Lindsay was at 28,000 feet when his maneuvering brought him close to a stall. Suddenly the F7U-3 went head over heels. Violently thrown about the cabin, Lindsay ejected and survived. Nine days later, Lieutenant Commander Bud Sickel investigated the flight regime that had caused the loss of Lindsey’s Cutlass. After tumbling 18,000 feet and trying every recovery technique he could think of, Sickel ejected.

“It was a pretty wild ride,” says Shelton. “He got out just in time for the parachute to open and landed in a plowed field and went in all the way up to his hips, which was the only thing that saved his ass.”

When Lieutenant Morrey Loso found himself in a similar situation, he let go of the stick and fumbled for the overhead ejection handles. To his astonishment, the Cutlass leveled off. Subsequent wind tunnel testing confirmed that the usual rules for exiting uncontrolled flight didn’t apply to the Cutlass. Just a little aft pressure on the stick, or let it go entirely: With enough altitude, the airplane would likely recover on its own. But by then, the Cutlass’ reputation was such that Vice Admiral Harold M. “Beauty” Martin, commander, air force of the U.S. Pacific Fleet, began replacing his squadrons’ Cutlasses with Grumman F9F-8 Cougars.

The decision caught F7U pilot Alex Sotir and others by surprise. “We are taxiing out and all of a sudden I see this jeep with a ladder go flying by me,” Sotir recalls. “The jeep stops the skipper and a guy runs up the ladder and hands the skipper an envelope. Next thing I know we are returning to the line and the skipper tells us the Navy is taking our aircraft away. They didn’t even want us to carrier-qualify in the Cutlass.”

A few years back, Sotir met some Navy pilots at a wedding reception and got to talking shop. “We asked each other the usual questions about our squadrons and which planes we had flown,” Sotir says. “When I told them Cutlasses, they looked at me…. They figured something had to be wrong with me.”

“The Cutlass could be made into a pretty good flying machine with a few modifications,” wrote F7U-3 pilot John Moore in The Wrong Stuff, about his Navy flying days. “Like a conventional tail, tripling the thrust, cutting the nosewheel strut in half, completely redoing the flight control system, and getting someone else to fly it.”

Even after Martin started his Cutlass purge, Chance Vought was still cranking out F7Us. Along with 180 F7U-3s, Vought built 98 -3Ms, the first aircraft in Navy inventory capable of carrying the Sparrow air-to-air missile. Vought also built a dozen -3P photo-reconnaissance Cutlasses, and tried to interest the Navy in 250 of the ground attack version, the A2U-1 (the Navy ordered them, then cancelled before production began).

Even those who liked the airplane admit it had its shortcomings, but maintain that if the Navy had spent the time and money to adequately address them as it had for airplanes like the Vought F-8 Crusader or the Douglas A-4 Skyhawk, the F7U could have been a sweeter ride. Supporters say it was a necessary step in the advancement of naval aviation, and that while the numbers were bad, so were the numbers of just about everything involving jet fighters and aircraft carriers in the early to mid-1950s.

“I liked flying the Cutlass,” says Don Shelton. “I checked out a lot of guys in it, and for the most part, once you got the guy above the threshold of fear and trepidation and got him in the air and flying, then he liked it.”

Dick Cavicke never encountered much fear and trepidation, even on his first day at VF-124, when a classmate from flight school crashed a few minutes into his first Cutlass flight. Cavicke bridled at a local newspaper’s attitude when announcing the end of the Cutlass: “The Miramar newspaper said, ‘VF-124 junks Cutlasses and gets new F3H Demons.’ That really torqued those of us who were flying the F7U-3,” he says. “So when the day came, being the maintenance officer of the squadron, I deemed it necessary that one of our Cutlasses needed a test flight, and a few minutes before the Demons were set to arrive, I come smoking by. My squadron buddies said it was a thing of beauty—the plane was totally shrouded in vapor. Soon after, the Demons, which were limited because of some early engine problems, came putt-putting by at a much slower speed.”

Ultimately, between June 1954 and December 1956, 13 fleet squadrons received Cutlasses. In 1957, Chance Vought analyzed major F7U-3 accidents. At 55,000 hours cumulative flight time, 78 accidents, and one-quarter of airframes lost, the Cutlass had the highest accident rate of all Navy swept-wing fighters.

DC Agle has flown a Cutlass. To this day his mother has no idea what happened to her car’s transmission and rear axle.

Like most Navy aircraft, the Cutlass’ huge slab of a wing folded for stowage on carrier decks. Vought Aircraft
The “Gutless Cutless” earned its nickname primarily from its underpowered engines. A Vought F7U-3 in May 1953. Greater St. Louis Air and Space Museum
Cutlass no. 128454, here fitted with an instrument test probe, underwent a series of nose jobs as engineers sought to improve visibility on approach to a carrier. Vought Aircraft
Harry Whitver
The Cutlasses of VF-124 line the deck of the USS Hancock. Vought Aircraft
Test pilots sometimes donned partial-pressure suits when flying the skittish Cutlass at high altitudes. US Navy
In July 1955 an F7U-3 hit the deck, broke apart, and slammed over the side of the Hancock. National Naval Aviation Museum
Even as a “static display,” the Cutlass, with its unique configuration and great size, was a hit at airshows. Vought Aircraft
The twin Westinghouse engines put on a fine light show at night, but that’s about all they could do. San Diego Air and Space Museum
The F7U’s nose gear strut was as inadequate as it looks to support the forward fuselage on landing. Vought Aircraft
Air Task Group 181 shows off (left to right) an FJ-3 Fury, F2H-3 Banshee, F7U-3M Cutlass, and F9F Cougar. National Naval Aviation Museum
Cutlass test pilot Whitey Feightner logged many sporty hours in F7Us. NASM (Web11788-2011)
The Cutlass achieved pop-culture status when it landed on the hoods of Chevy Bel Airs. web4camguy

Get the latest stories in your inbox every weekday.